Pecky's Vauxhall Decoder

Results 1 to 3 of 3
  1. #1
    Member Daver944's Avatar
    Join Date
    Aug 2016
    Location
    Southampton
    Posts
    1
    Vehicle
    Zafira B 2007 1.6 life

    Zafira B Fault code ECN160638

    Hi from newbie, I have 2007 Zafira 16 Life, approx. 80000 miles.

    For the past 12 months the engine management light (orange) has been on and off intermittently; car has run fine during this period. (Fault code 0171: i've cleaned the inlet manifold and checked the operation of the EGR valve)
    Occasionally it has refused to start (maybe twice in the past year), but after being left for a few days it starts and runs fine.

    Last week we were on holiday in UK and used the car to drive from Southampton to Essex and back which it did with no problems.

    The day after we returned we went to start the car; it refused to start and seemed to spit back in the air cleaner.

    Later that day I tried again; the engine would start and race to ~5000rpm for about 2 seconds then cut-out. (without touching the throttle pedal). it has done this repeatedly since.

    Occasionally it will run at approx. 1000rpm making 'strange' noises (not very technical description) and again after about 2 seconds then cuts out.

    The faults (using the pedal trick) were:
    17152 Which I assume is the EGR valve or the ports in the cylinder head
    P0201
    P0202
    P0203
    P0204
    160638

    After again cleaning the EGR valve (didn't seem to need cleaning) I checked the fault codes and now have 160638.

    The battery voltage is good (12,5 volts), I have taken the electrical panel (with fuses and relay) off and checked for corrosion: I couldn't see any, but sprayed some electrical cleaner anyway for good measure.
    I have taken the connectors off the ECU: they are clean with no signs of corrosion.

    from various forums it looks like a new ECU is required: any comments from the experts out there?


    • Advertising

      advertising
      Diagnostics.org.uk
      has no influence
      on advertisments
      that are displayed by
      Google Adsense

    • #2
      Member liviu2004's Avatar
      Join Date
      Feb 2014
      Location
      Netherlands
      Posts
      150
      Vehicle
      Opel
      P0606 Replace Electronic Control Unit (ECU)
      P0606 Capacitor Voltage 1 Low Voltage
      P0606 Capacitor Voltage 1 High Voltage
      P0606 Electronic Control Unit (ECU) - Malfunction
      The control unit recognises an internal control unit malfunction or is influenced by interference voltage from the following component: A40 Ignition Coil - Direct Ignition
      P0606 System Voltage High Input >17V
      P0606 Control Unit Re-Initialisation

    • #3
      Member nikh667's Avatar
      Join Date
      Nov 2016
      Location
      Bodmin
      Posts
      12
      Vehicle
      Astra 1.9CDTi
      Did you find a resolution to this?

      P1606 (Symptom Byte 38) is for "Engine Torque Not Plausible" - this will tie in with the P0171 fuel system issue and also the symptoms you're getting with the running problems. It doesn't sound ECM related to me, moreso something along the lines of an intake air leak affecting the reading to the MAP sensor, which will throw the fuelling off right across the whole rev range.

Similar Threads

  1. Zafira Fault Code with Pedal Test ECN 111606
    By anthmills2000 in forum Zafira
    Replies: 1
    Last Post: 19th November 2014, 11:06 PM
  2. fault code RXE
    By mookev in forum Astra
    Replies: 1
    Last Post: 11th August 2013, 10:14 PM
  3. Zafira B fault code p2279
    By Griff in forum Zafira
    Replies: 3
    Last Post: 3rd May 2013, 12:17 PM

Visitors found this page by searching for:

engine torque not plausible

ecn 160638

zafira fault codes 160638

07 zafira 1.6 error codes p0171. 0201 0202 .0203 .0204 .

zafira pedal test 0171

fault code 160638

2007 vauxhall zafira p1606 engine torque implausible

SEO Blog

Tags for this Thread

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  
About us
This site was created by Pecky to act as a knowledge base of useful information regarding Vauxhall cars.
Whilst I can help out with works, this isn't my full time job, so occasionally there may be a delay in replying.

Other forums

AOC, AON, VXR-Online, Insignia-drivers.uk

Diagnostics.org.uk is a trading name of RJP Projects Ltd which is a company registered in England and Wales with company number 7453778